Method for determining the physical stability of shrimp feeds in water

By L. Obaldo, S. Divakaran, A. Tacon. 2002

132 citations recorded by the source corpus.

Three methods for measuring the water stability and leaching characteristics of shrimp pelleted feeds were developed and tested: static water method, horizontal shaking method and vertical shaking method. Each method was tested using a commercial and experimental pelleted shrimp feed. Both feeds had a pellet size of 2.4 mm × 5.0 mm with similar proximate composition (35% protein and 9% fat). Each test run consisted of leaching c. 2 g of feed at six intervals of immersion time (0, 30, 60, 120, 240, 360 min), two concentrations of salinity (0, 34 ppt), and three different water temperatures (15, 25, 35 °C). A refrigerated circulating water bath was used to maintain the desired level of water temperature. For the static water and horizontal shaking methods, a Buchner filtration apparatus with Whatman filter paper no. 3 (5 μ) was used to separate the remaining pellets from leached water. The vertical shaking method (VanKel) utilized a perforated stainless-steel basket (381 μ) for leaching and serving as a filter to separate pellets from leached water. For all three methods, the leached feed and original feed samples were dried in a convection oven at 105 °C for 24 h and then cooled in a desiccator. Dried feed samples were weighed and analysed for dry matter retention. Pellet stability was calculated as the ratio of dry matter retention after leaching and dry matter of original samples expressed as a percentage. Results indicated that any method for pellet stability analysis should take into account water temperature and salinity in addition to actual pellet agitation rate to obtain accurate and consistent measurement of pellet disintegration and nutrient leaching. Dry matter retention was different for each shrimp feed with experimental feed (72.8%) showing lower retention than commercial feed (88%) after 6 h of VanKel leaching under normal shrimp culture conditions. The three methods provided reproducible results with both horizontal and vertical shaking methods recommended for routine laboratory analysis because they could provide different degrees of pellet agitation that simulate actual indoor and outdoor shrimp culture conditions.

Subfields: Aquatic Science, Global and Planetary Change, Immunology

View Paper: https://www.semanticscholar.org/paper/715e8bfd58b2a13b7d253f8760c51f21a2ead196

How researchers see this paper

The researchers whose trusted networks rank it highest, strongest advocate first. Every researcher gets a different order.

In Aquatic Science

  1. G. Cuzon
  2. G. Gaxiola
  3. C. Rosas
  4. C. Pascual

In Global and Planetary Change

  1. C. Rosas
  2. G. Gaxiola
  3. C. Pascual

Citations in the corpus